B5.9G, B5.9LPG, B Gas Plus, B LPG Plus – 003-021   Crankcase Ventilation Filter

Table of Contents

General Information
Remove
Install

General Information

TOC

 WARNING 

To reduce the possibility of personal injury, avoid direct contact of hot oil with your skin.
 WARNING 

Some state and federal agencies have determined that used engine oil can be carcinogenic and cause reproductive toxicity. Avoid inhalation of vapors, ingestion, and prolonged contact with used engine oil. If not reused, dispose of in accordance with local environmental regulations.

Refer to the Procedure 102-002 (Maintenance Schedule) in Section 2 of the Operation and Maintenance Manual B5.9G, B5.9LPG, B Gas Plus, B LPG Plus, and B Gas International Engines, Bulletin 3666112 for your engine, for the crankcase ventilation filter service interval.Refer to the Procedure 102-002 (Maintenance Schedule) in Section 2 of the Operation and Maintenance Manual C8.3G, C Gas Plus, and L Gas Plus Engines, Bulletin 3666183 for your engine, for the crankcase ventilation filter service interval.

 
SMALL | MEDIUM | LARGE

Remove

TOC

Release the clamps (1) on the closed-crankcase ventilation canister.

SMALL | MEDIUM | LARGE
   


Pull the canister down to a point where the filter can be loosened.

SMALL | MEDIUM | LARGE
   


Remove both the filter and canister from the closed-crankcase ventilation unit.

SMALL | MEDIUM | LARGE
   


 WARNING 

Some state and federal agencies have determined that used engine oil can be carcinogenic and cause reproductive toxicity. Avoid inhalation of vapors, ingestion, and prolonged contact with used engine oil. If not reused, dispose of in accordance with local environmental regulations.

Discard any excess oil in the bottom of the canister.

SMALL | MEDIUM | LARGE
   

Install

TOC

Replace the filter and o-ring on the upper stem of the filter.

NOTE: Be sure that the old o-ring has not been jammed within the closed-crankcase ventilation head before installing.

SMALL | MEDIUM | LARGE
   


Push the filter and canister back into position on the closed-crankcase ventilation unit.

SMALL | MEDIUM | LARGE
   


Fasten the clamps (1).

SMALL | MEDIUM | LARGE
Last Modified:  15-Aug-2007